User manual SHOPRIDER SPRINTER XL4 DELUXE

[. . . ] Heavy Duty Scooters SPRINTER XL4 (889B-4) SPRINTER XL3 DELUXE (889-3XLS) SPRINTER XL4 DELUXE (889-4XLS) SPRINTER JUMBO XL (889X) User Manual Contents INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 FEATURE GUIDE (FIG. 1-4) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 SAFETY ADVICE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 EMI Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 ADJUSTMENTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Tiller Angle Adjustment (Fig. 5) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Seat Slide & Swivel Adjustment (Fig. 6). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Seat Removal (Fig. [. . . ] Refit the pin into one of the five location holes to lock tiller in place. 6) Pulling up on the seat black slide lever allows the seat position to be adjusted forward or backward. Pulling up on the lever allows the seat to swivel, when released the seat will lock into one of four positions. The seat height can be adjusted to 5 different settings by inserting the steel locking pin in the required hole. 8) On the underside of the seat there are two hand knobs, one either side. Loosening the hand knob allows the arm rest to be adjusted to the required width, or removed for transportation. DO NOT USE SCOOTER WITHOUT THE ARM RESTS BEING FITTED & SECURED. Tiller Angle Adjustment Lever Figure 5 Swivel Seat Adjustment Lever Seat Slide Lever Figure 6 Seat Adaptor Seat Tightening Hand Knob Seat Locking Pin Figure 7 Armrest Adjustment Hand Knob Figure 8 8 12/29/2004 Armrest Angle Adjustment (Fig. 9) Flip up the armrests to allow access to the adjustment screw and lock nut, unscrew the lock nut and screw the bolt in or out to increase or decrease the angle. The armrests are set parallel to the floor at the factory. Locking Nut and Bolt Adjustment Screw Figure 9 Reclining Seat (Fig. 10) Sprinter XL4 Deluxe & Sprinter XL3 Deluxe The Sprinter XL4 Deluxe and Sprinter XL3 Deluxe come standard with a reclining seat. The reclining seat lever is located on the left side below the armrest. 11A, 11B & 11C) Speed Controls The speed control dial allows you to set a speed Speed Control between 1 (minimum) and 10 (maximum). The Sprinter XL3 Deluxe, XL4 Deluxe, and Jumbo XL are also equipped with a speed high/low switch. Battery Level Indicator Key Switch Battery Level Indicator/Gauge The number of LED bars lit/where the needle rests, shows the amount of charge left in your batteries. The amount of charge will only show at its true level when the scooter is in drive. CAUTION ­ Do not allow the LED bars/gauge needle go out/down completely as complete discharge of the batteries could cause irreversible damage. Horn A yellow button located at the tiller controls operates the horn. Thumb/Finger Accelerator Lever Controls The right thumb/finger accelerator lever controls the forward motion and the left thumb/finger accelerator lever controls the reverse motion. The amount of pressure applied to each lever will determine the speed the scooter travels at. Turn the key and the LED bars will light up/needle gauge will move to the right. There is a delay before the thumb/finger lever accelerator control can be operated, while the controller checks the circuits. Indicator Switch Sprinter XL4/XL3 Deluxe, Sprinter Jumbo XL Thumb Lever Control Horn Figure 11A Sprinter XL4 Light Indicator Switch Charging Port Finger Lever Control Speed Controls Battery Level Indicator Speed High/Low Switch Hazard Lights Lights Horn Key Switch Figure 11B Sprinter XL3 Deluxe & Sprinter XL4 Deluxe Charging Port Indicator Switch Battery Level Indicator Finger Lever Control Key Switch High/Low Switch Lights Horn Speed Controls Operates turn indicator lights. [. . . ] Ensure that when refitting the wheel the retaining bolt is fitted with a locking washer or the screw threads are treated with lock-tite or a similar adhesive. Tire pressure is recommended to be kept at 30 psi on the rear tires, and 25 psi on the front. General Scooter Maintenance Every six months check the tiller base bolts, wheel axle bolts, and arm rest angle adjustment bolts and tighten as necessary. Also check the seat and arm rest tightening knobs and tighten as needed. [. . . ]