User manual DA-LITE PLC38E SHEMATICS

[. . . ] To reduce the risk of electric shock, do not disassemble this appliance. Incorrect reassembly can cause electric shock when the appliance is used subsequently. The use of an accessory attachment not recommended by the manufacturer may cause a risk of fire, electric shock, or injury to persons. SAVE THESE INSTRUCTIONS PRE-INSTALLATION 1. [. . . ] The use of an accessory attachment not recommended by the manufacturer may cause a risk of fire, electric shock, or injury to persons. SAVE THESE INSTRUCTIONS PRE-INSTALLATION 1. Make sure to recheck measurements of screen location before installation. SCREW FOR SECURING ROLLER ACCESS DOOR FABRIC DOOR ACCESS DOOR FIGURE 1 CASE INSTALLATION 1. The case provides multiple attachment points for bolts, cables, or threaded rod. The variable position-mounting bracket may be located anywhere along the length of the case. It is recommended to keep the brackets spaced evenly enough to distribute the weight of the screen. Ceiling tiles or drywall may be placed on top of this flange to provide a finished appearance. After securing the case in the ceiling check that the case is level and plumb. s CONTACT DA-LITE AT 800-622-3737 OR 574-267-8101 IF SCREEN OR DOOR MOTOR NEEDS ADjUSTMENT. 2 TENSIONED ADVANTAGE® DELUXE ELECTROL® INSTRUCTIONS FOR STANDARD CONTROL FRONT OF WALL SWITCH BACK OF WALL SWITCH 120V WIRING DIAGRAM NOTE: Electrical connections on left end of case. UP STOP DOWN NOTE: 20-24AWG WIRE RECOMMENDED FOR CONNECTING WALL SWITCH TO THE DUAL MOTOR CONTROLLER RED (UP) BLACK (DOWN) WHITE (COMMON) OPTIONAL RF OR IR REMOTE CONNECTOR NOT USED BLACK (DOWN) RED (UP) WHITE (COMMON) NOT USED WHITE (COMMON) RED (UP) BLACK (DOWN) GREEN (GROUND) WHITE (COMMON) RED (UP) BLACK (DOWN) GREEN (GROUND) WHITE (COMMON) AUX EYE BLACK (DOWN) RED (UP) POWER INPUT 120VAC/60HZ BLACK (HOT) GREEN (GROUND) WHITE (COMMON) SCREEN MOTOR RED (DOWN) BLACK (UP) WHITE (COMMON) WHITE (COMMON) RED (DOWN) BLACK (UP) GREEN (GROUND) WHITE (COMMON) RED (DOWN) BLACK (UP) GREEN (GROUND) NOT USED DOOR MOTOR DOOR MICROSWITCH 220/240V WIRING DIAGRAM NOTE: Electrical connections on left end of case. FRONT OF WALL SWITCH UP BACK OF WALL SWITCH STOP DOWN NOTE: 20-24AWG WIRE RECOMMENDED FOR CONNECTING WALL SWITCH TO THE DUAL MOTOR CONTROLLER RED (UP) BLACK (DOWN) WHITE (COMMON) OPTIONAL RF OR IR REMOTE CONNECTOR NOT USED BLACK (DOWN) RED (UP) WHITE (COMMON) NOT USED BLUE (COMMON) BLACK (UP) BROWN (DOWN) GREEN/YELLOW (GROUND) BLUE (COMMON) BLACK (UP) BROWN (DOWN) GREEN/YELLOW (GROUND) BLUE (COMMON) AUX EYE BROWN (DOWN) BLACK (UP) POWER INPUT 240VAC/50HZ BROWN (HOT) GREEN/YELLOW (GROUND) BLUE (COMMON) SCREEN MOTOR BLACK (DOWN) BROWN (UP) BLUE (COMMON) BLUE (COMMON) BLACK (DOWN) BROWN (UP) GREEN/YELLOW (GROUND) BLUE (COMMON) BLACK (DOWN) BROWN (UP) GREEN/YELLOW (GROUND) NOT USED DOOR MOTOR DOOR MICROSWITCH 3 TENSIONED ADVANTAGE® DELUXE ELECTROL® INSTRUCTIONS SCB-100 CONTROL NOTE: Electrical connections on right side of case. 120V WIRING DIAGRAM BLACK (HOT) POWER INPUT AND CONTROL BOARD ARE LOCATED ON RIGHT SIDE OF SCREEN HOUSING. POWER INPUT 120VAC/60HZ GREEN (GROUND) WHITE (COMMON) BLACK (HOT) GREEN (GROUND) WHITE (COMMON) TERMINAL BLOCK TX G RX TX G RX - DATA OUT - GROUND - DATA IN - DATA OUT - GROUND - DATA IN WHITE (COMMON) BLACK (DOWN) RED (UP) - 12VDC OUT + 12VDC OUT WHITE (COMMON) WHITE (COMMON) WHITE (COMMON) RED (UP) GRAY (DOOR) BLACK (DOWN) GREEN (GROUND) RED (UP) GRAY (DOOR) BLACK (DOWN) GREEN (GROUND) WHITE (COMMON) RED (DOWN) BLACK (DOWN) RED (UP) BACK OF WALL SWITCH FRONT OF WALL SWITCH UP STOP SCREEN MOTOR WHITE (COMMON) RED (DOWN) BLACK (UP) GREEN (GROUND) BLACK/ YELLOW DOWN BLACK (DOWN) WHITE (COMMON) BLACK (UP) NOTE: 20-24AWG WIRE RECOMMENDED FOR CONNECTING WALL SWITCH TO THE DUAL MOTOR CONTROLLER NOT USED DOOR MOTOR SCREEN AND DOOR MOTOR, MICROSWITCH AND TIMER RELAY ARE LOCATED ON LEFT SIDE OF SCREEN HOUSING. DOOR MICROSWITCH NOTE: Electrical connections on right side of case. 220 / 240V WIRING DIAGRAM BROWN (HOT) POWER INPUT AND CONTROL BOARD ARE LOCATED ON RIGHT SIDE OF SCREEN HOUSING. POWER INPUT 240VAC/50HZ GREEN/YELLOW (GROUND) BLUE (COMMON) BROWN (HOT) GREEN/YELLOW (GROUND) BLUE (COMMON) TERMINAL BLOCK TX G RX TX G RX - DATA OUT - GROUND - DATA IN - DATA OUT - GROUND - DATA IN WHITE (COMMON) BLACK (DOWN) RED (UP) - 12VDC OUT + 12VDC OUT BLUE (COMMON) BLUE (COMMON) BLUE (COMMON) BLACK (UP) GRAY (DOOR) BROWN (DOWN) GREEN/YELLOW (GROUND) BLACK (UP) GRAY (DOOR) BROWN (DOWN) GREEN/YELLOW (GROUND) BROWN (DOWN) BLUE (COMMON) BLACK (DOWN) BLACK (UP) BACK OF WALL SWITCH FRONT OF WALL SWITCH UP SCREEN MOTOR BLUE (COMMON) BLACK (DOWN) BROWN (UP) GREEN/YELLOW (GROUND) BROWN/ YELLOW STOP DOWN BROWN (DOWN) BLUE (COMMON) BROWN (UP) NOTE: 20-24AWG WIRE RECOMMENDED FOR CONNECTING WALL SWITCH TO THE DUAL MOTOR CONTROLLER NOT USED DOOR MOTOR SCREEN AND DOOR MOTOR, MICROSWITCH AND TIMER RELAY ARE LOCATED ON LEFT SIDE OF SCREEN HOUSING. DOOR MICROSWITCH 4 TENSIONED ADVANTAGE® DELUXE ELECTROL® INSTRUCTIONS SCB-200 CONTROL NOTE: Electrical connections on right side of case. 120V WIRING DIAGRAM BLACK (HOT) POWER INPUT AND CONTROL BOARD ARE LOCATED ON RIGHT SIDE OF SCREEN HOUSING. BLACK (HOT) GREEN (GROUND) WHITE (COMMON) POWER INPUT 120VAC/60HZ GREEN (GROUND) WHITE (COMMON) RED (UP) BLACK (DOWN) WHITE (COMMON) WHITE (COMMON) WHITE (COMMON) WHITE (COMMON) RED (UP) GRAY (DOOR) BLACK (DOWN) GREEN (GROUND) RED (UP) GRAY (DOOR) BLACK (DOWN) GREEN (GROUND) ENCODER 5V A B GND WHITE (COMMON) RED (DOWN) BLACK (DOWN) RED (UP) B+ A - SCREEN MOTOR WHITE (COMMON) RED (DOWN) BLACK (UP) GREEN (GROUND) BLACK/ YELLOW BLACK (DOWN) WHITE (COMMON) BLACK (UP) NOT USED DOOR MOTOR SCREEN AND DOOR MOTOR, MICROSWITCH AND TIMER RELAY ARE LOCATED ON LEFT SIDE OF SCREEN HOUSING. DOOR MICROSWITCH NOTE: Electrical connections on right side of case. 220 / 240V WIRING DIAGRAM BROWN (HOT) POWER INPUT AND CONTROL BOARD ARE LOCATED ON RIGHT SIDE OF SCREEN HOUSING. POWER INPUT 240VAC/50HZ BROWN (HOT) GREEN/YELLOW (GROUND) BLUE (COMMON) GREEN/YELLOW (GROUND) BLUE (COMMON) BLACK (UP) BROWN (DOWN) BLUE (COMMON) BLUE (COMMON) BLUE (COMMON) BLACK (UP) GRAY (DOOR) BROWN (DOWN) GREEN/YELLOW (GROUND) BLUE (COMMON) BLACK (UP) GRAY (DOOR) BROWN (DOWN) GREEN/YELLOW (GROUND) ENCODER 5V A B GND BLUE (COMMON) BLACK (DOWN) BROWN (DOWN) BLACK (UP) B+ A - SCREEN MOTOR WHITE (COMMON) RED (DOWN) BLACK (UP) GREEN (GROUND) BROWN/ YELLOW BROWN (DOWN) BLUE (COMMON) BROWN (UP) NOT USED DOOR MOTOR SCREEN AND DOOR MOTOR, MICROSWITCH AND TIMER RELAY ARE LOCATED ON LEFT SIDE OF SCREEN HOUSING. DOOR MICROSWITCH 5 TENSIONED ADVANTAGE® DELUXE ELECTROL® INSTALLATION 7-1/4" vARIABLE POSITION CASE LENGTH MOUNTING BRACKETS 7-1/4" 7-5/8" MOTOR END ELECTRICAL JUNCTION BOx 7-5/8" FLAT bRACkET MOUNTING METhOD 9-1/4" (SUGGESTED) 3/8" THREADED ROD (NOT INCLUDED) ATTACHED TO MOUNTING BRACKET 7-1/4" SELF-TRIMMING FLANGE 8-3/4" FINISHED CEILING SEE DETAIL A FORMED bRACkET MOUNTING METhOD 4. 59" (SUGGESTED) 3/8" THREADED ROD (NOT INCLUDED) 7. 21" HANGER BRACKET DETAIL A 8. 75" 8. 74" 6 TROUBLESHOOTING Visit www. da-lite. com/products/tutorials. php to find installation and troubleshooting tutorials. You will also find a link to Live Chat for interactive support and you can contact us by email at info@da-lite. com or by phone at (800) 622-3737 or (574) 267-8101 with any troubleshooting questions. SYMPTOM If screen is not responding properly and SCB100 or SCB200 controls are used, contact the factory for troubleshooting assistance. "Down" Position Check for power across black and white leads. "Up" Position Check for power across red and white leads. (b) Blown facility fuse. (d) No power to operating switch or junction box. (e) Open door limit switch. CAUSE (a) Hinge is bound or has a foreign substance on it which does not allow it to open by gravity. (a) Check all wiring and connections. 8 9 10 LIMITED ONE YEAR WARRANTY ON DA-LITE PRESENTATION PRODUCTS Da-Lite Screen Company, Inc. [. . . ] (d) No power to operating switch or junction box. (e) Open door limit switch. CAUSE (a) Hinge is bound or has a foreign substance on it which does not allow it to open by gravity. (a) Check all wiring and connections. 8 9 10 LIMITED ONE YEAR WARRANTY ON DA-LITE PRESENTATION PRODUCTS Da-Lite Screen Company, Inc. [. . . ]