User manual AEG-ELECTROLUX GL30EN

[. . . ] Use & Care Manual Assembly Instructions Included 30" Stainless Steel Outdoor Grill with Electronic Ignition Welcome/Product Registration 1 General Safety Instructions 2 Grill Features and Components Grill Assembly Built-In Instructions Gas Requirements Leak Testing 3-4 5-8 9-11 Lighting the Grill Using the Grill Rotisserie/Side Burner Usage 12 13-15 Care & Maintenance 16 Troubleshooting Your Grill 17-18 Visit the Frigidaire Web Site at: http://www. frigidaire. com Warranty 19 READ AND SAVE THESE INSTRUCTIONS Welcome & Congratulations Congratulations on your purchase of a new grill!We at Electrolux Home Products are very proud of our product and we are completely committed to providing you with the best service possible. It contains valuable information on how to properly maintain your new grill. We know you'll enjoy your new grill and thank you for choosing our product. [. . . ] Most gas tanks now come equipped with a leak detector mechanism internal to the tank, when gas is allowed to escape rapidly it shuts off the gas supply. Opening the valve rapidly may simulate a gas leak, causing the safety device to activate, restricting gas flow causing low flames. Opening the valve slowly will insure this safety feature is not falsely triggered. · When not in use, gas supply cylinder valve is to be in the "OFF" position. · The tank supply system must be stored upright to allow for vapor withdrawal. · The regulator and hose assembly must be inspected before each use of the grill. If there is excessive abrasion or wear or if the hose is cut, it must be replaced prior to the grill being used again. · Cylinders must be stored outdoors out of the reach of children and must not be stored in a building, garage or any other enclosed area. gas cylinder under or near the grill. 10 Pre Operation Leak Testing GENERAL INFORMATION Although all gas connections on the grill are leak tested prior to shipment, a complete gas tightness check must be performed at the installation site due to possible shifting during shipment, installation or excessive pressure unknowingly being applied to the unit. Periodically check the whole system for leaks and immediately check the system if the smell of gas is detected. Mix a solution of equal parts mild detergent or liquid soap and water. Turn the top knob of the fuel supply cylinder counterclockwise (right to left) two (2) rotations to open. If a leak is detected, immediately turn off the gas supply, tighten any leaking fittings, turn gas on, and repeat steps 1-3. Turn on the burner control knobs for a moment to release the pressure in the hose, then turn the control knobs back off. Check all gas supply fittings before each use and each time the gas supply cylinder is connected to the regulator. Have a qualified service technician leak test the grill any time a part of the gas system is replaced. Also it is recommended to perform a leak test at least once a year whether or not the L. P. NOTE: When leak testing this appliance, make sure to test and tighten all loose connections, including the side burner. A slight leak in the system can result in a low flame, or hazardous condition. gas tanks now come equipped with a leak detector mechanism internal to the tank, when gas is allowed to escape rapidly it shuts off the gas supply. A leak may significantly reduce the gas flow making the grill difficult to light or causing low flames. NOTE: If you cannot stop a gas leak turn off the gas supply and call your local gas company or the dealer you purchased the appliance from. [. . . ] · If only one burner appears low, check and clean the burner ports if clogged or dirty. Flame is erratic · Check gas connection - look for kinked hose. Flare-ups · Check flavor grids and cooking grates for excess food or grease build-up. · Be sure drip tray is clean, (do not use aluminum foil on drip tray. ) Note: Some flare-ups may be inevitable if cooking greasy foods. [. . . ]